Suzuki sj 410 from Cornwall PROJECT Never Ending Project

Post by **Jordi** » Sun Mar 03, 2013 10:34 pm

The springs i've got look a lot better than whats on. Just gotta swap em.

Couldn't afford new springs right now. Spent a shed load on both of them recently.

Just took a closer look at them photos. Looks really tidy in the back of that Zuk was the floor all solid or has it been repaired?

dazerede · Post by **dazerede** » Sun Mar 03, 2013 10:45 pm

It's been all repaired and had tons of paint
The worst bit was around the corners
Wats left to do on my sj
Put some fabric on.the roof inside
And stick fabric on my sun visors
Sand down and re-spray my bumpers waiting for a hot day
Not sure yet shall I remove the arch exstensions as wheels on stick out by like 2 inches I've seen worst
In like 2 years Maby roller my sj the same colour as I want the paint to be thicker
And last but least wire my spit lights up

dazerede · Post by **dazerede** » Fri Mar 29, 2013 7:15 pm

Spot lights are all wired up

finally took about 5 months
Wired it through a relay a switch and a fuse straight to the battery
And a pic of the switch its the one illuminated

the other switch next to the isolator switch is the fog switch wich also illuminates up

OllieSJ · Post by **OllieSJ** » Fri Mar 29, 2013 11:46 pm

Nice

dazerede · Post by **dazerede** » Sat Mar 30, 2013 2:36 pm

Guess where I found this hole to

turbo-tom · Post by **turbo-tom** » Sat Mar 30, 2013 4:43 pm

looks like petrol tank to me ?

dazerede · Post by **dazerede** » Sat Mar 30, 2013 8:11 pm

Yep it is the petrol tank

Good job I seen.it before I filled it up all ready wacked in 12 liters of petrol so far
It has been repaired using this leak fix

Click Here for Ebay Listing

turbo-tom · Post by **turbo-tom** » Sat Mar 30, 2013 8:15 pm

fare enough i wouldnt go by that stuff to be honest it might get you out the shit for a bit but if i was you i would take the tank off , drain it all , some how clean it inside out fill it up with water then weld it up and wait a week or so to dry it out then put some fresh petrol in slosh it around drain it out and re bolt it back up and job should be a gooden

dazerede · Post by **dazerede** » Sat Mar 30, 2013 9:03 pm

I havnt bought the stuff I had a bit liying around and I seen it say it can fix radiators and fuel tanks
So I tried it
I cleaned it out scrubbed it and painted it last year and fresh petrol shame I have to do it again

dazerede · Post by **dazerede** » Fri Apr 12, 2013 6:01 pm

Postman came today new set of Polly bushes from flo-flex

Suzuki Club UK

Suzuki sj 410 from Cornwall PROJECT Never Ending Project

Re: suzuki sj 410 from cornwall PROJECT New Wheels :)

Re: suzuki sj 410 from cornwall PROJECT New Wheels :)

Re: Suzuki sj 410 from Cornwall PROJECT Never Ending Project

Re: Suzuki sj 410 from Cornwall PROJECT Never Ending Project

Re: Suzuki sj 410 from Cornwall PROJECT Never Ending Project

Re: Suzuki sj 410 from Cornwall PROJECT Never Ending Project

Re: Suzuki sj 410 from Cornwall PROJECT Never Ending Project

Re: Suzuki sj 410 from Cornwall PROJECT Never Ending Project

Re: Suzuki sj 410 from Cornwall PROJECT Never Ending Project

Re: Suzuki sj 410 from Cornwall PROJECT Never Ending Project

test