Ed's wagon
-
Tramp
- Suzuki, will you marry me?
- Posts: 2828
- Joined: Fri Jul 25, 2008 10:09 pm
- Location: Rotherham - South Yorkshire
Re: Ed's wagon
Ahh makes sense, if mine failed I'd do exactly the same! Tbh the light switch will be the culprit, take the door strap off then open it up so you can get in the hinge and remove the switch, clean the contacts with some emery paper and it will be fixed, my only other advice is do it before it's crushed, I imagine getting to the switch whilst the cars a cube might make the job a lot harder
Re: Ed's wagon
They worked when they left the factory?!?Edweird wrote:Bad news gentlemen. My Zook's courtesy light has stopped working when I open the door so I'm going to have to scrap my SJ.
Well every days a school day.
Andys Rusty Suzuki Emporium
-
Jordi
- Bow down before me
- Posts: 7532
- Joined: Sun Nov 29, 2009 2:35 pm
- Location: Darlington, Co. Durham
Re: Ed's wagon
Strange, mine has decided to start working afters several years of not working.Edweird wrote:Bad news gentlemen. My Zook's courtesy light has stopped working when I open the door so I'm going to have to scrap my SJ.
1988 Samurai - Truck Cab & Tray Back - 1.6 8v & HIF44 - Snorkel - Stack Exhaust - PAS, YJs & 33s - Trussed, Gusseted & Pumpkin Capped Axles - 4.3 R&Ps - 4.16 T/Box - Rear Air Locker - Full Float Back Axle & Discs - RCV Front Shafts - X-Eng Handbrake - Custom Fuel Tank
-
Ladaman
- Suzuki Guru
- Posts: 1090
- Joined: Thu Sep 08, 2011 10:56 pm
- Location: Huddersfield, W. Yorkshire
- Contact:
Re: Ed's wagon
What's one of those, you poser!Edweird wrote:Bad news gentlemen. My Zook's courtesy light has stopped working when I open the door so I'm going to have to scrap my SJ.
YouTube
Ignis Sport 1.5 16V; Jimny gearbox, 410 transfer box; 5.125:1 Vitara diffs; rear Lockright, Rob Storr full float rear axle, rear discs, YJ springs, virtual lift, 31" Grizzly Claws, beadlock rims, +50mm LR arches, LED rear lights, LED roof spots, bucket seats, Luke harnesses, internal cage
Ignis Sport 1.5 16V; Jimny gearbox, 410 transfer box; 5.125:1 Vitara diffs; rear Lockright, Rob Storr full float rear axle, rear discs, YJ springs, virtual lift, 31" Grizzly Claws, beadlock rims, +50mm LR arches, LED rear lights, LED roof spots, bucket seats, Luke harnesses, internal cage
-
twiss
- SCUK Computer Wizard
- Posts: 6110
- Joined: Mon Nov 08, 2010 2:28 pm
- Location: Birkirkara, Malta
- Contact:
Re: Ed's wagon
Switch + hammer = fixed!Edweird wrote:Bad news gentlemen. My Zook's courtesy light has stopped working when I open the door so I'm going to have to scrap my SJ.
Twiss
'93 Suzuki Samurai Sport 1.6 16v SU. Virtual lift, spring under, 31s
'93 Maruti Gypsy MG410
"If brute force doesn't fix your problem, you aren't using enough of it."
'93 Suzuki Samurai Sport 1.6 16v SU. Virtual lift, spring under, 31s
'93 Maruti Gypsy MG410
"If brute force doesn't fix your problem, you aren't using enough of it."
-
Edweird
- Suzuki, will you marry me?
- Posts: 2531
- Joined: Sat Jan 23, 2010 11:04 pm
- Location: Brigg, North Lincolnshire
Re: Ed's wagon
Nothing much going on but I thought folks might be pleased to hear that my SJ sailed through its MOT yesterday. Adjusted the carb a bit with the emissions tester in before they tested it. Went from 7.5% CO and about 700ppm of unburnt fuel to 1.6% CO and 195ppm (pass is less than 3.5% CO and 1200ppm).
What I have noticed is that as a result of the carb tuning then engine runs on a little bit sometimes when I turn off the ignition. I've got it sucking warm air because of the cold weather so I reckon that it's probably that plus it being relatively well tuned that is making it run on.
What I have noticed is that as a result of the carb tuning then engine runs on a little bit sometimes when I turn off the ignition. I've got it sucking warm air because of the cold weather so I reckon that it's probably that plus it being relatively well tuned that is making it run on.
There's three ways of doing things:
The right way,
The wrong way
And my way, which is like the wrong way but faster.
The right way,
The wrong way
And my way, which is like the wrong way but faster.
Re: Ed's wagon
good stuff! congrats
It's not a question of how much you spend on your suzuki, but when your money will run out
-
twiss
- SCUK Computer Wizard
- Posts: 6110
- Joined: Mon Nov 08, 2010 2:28 pm
- Location: Birkirkara, Malta
- Contact:
Re: Ed's wagon
tune the engine back to how you like it, just keep note of the adjustment you make for MOT time 
Twiss
'93 Suzuki Samurai Sport 1.6 16v SU. Virtual lift, spring under, 31s
'93 Maruti Gypsy MG410
"If brute force doesn't fix your problem, you aren't using enough of it."
'93 Suzuki Samurai Sport 1.6 16v SU. Virtual lift, spring under, 31s
'93 Maruti Gypsy MG410
"If brute force doesn't fix your problem, you aren't using enough of it."
Re: Ed's wagon
Running on is usually a timing problem but it could be that you're running too lean.
2006 Jimny JLX+ 1.3 VVT
2000 Vitara 4u2 - Calmini 3+3, 33" MTs, 5:83 R&Ps, winch bumper, remapped ECU.
1986 Suzuki SJ413K - G16 conversion
1984 Suzuki SJ410 - Blitz
2000 Vitara 4u2 - Calmini 3+3, 33" MTs, 5:83 R&Ps, winch bumper, remapped ECU.
1986 Suzuki SJ413K - G16 conversion
1984 Suzuki SJ410 - Blitz