Transfer box gear lever shake
Transfer box gear lever shake
Hi. SJ413 Santana: When traveling at speed, that is, about 60 mph, the transfer box gear lever shakes around like crazy, is that normal or a sign of a problem? Tia!
-
Jordi
- Bow down before me
- Posts: 7535
- Joined: Sun Nov 29, 2009 2:35 pm
- Location: Darlington, Co. Durham
Re: Transfer box gear lever shake
Is it the lever or the whole box?
The rubber mounts might have broke, have a look underneath and try to give the transfer box a shake. Easy and reasonably cheap fix. Llama 4x4 do replacement mounts if required.
The rubber mounts might have broke, have a look underneath and try to give the transfer box a shake. Easy and reasonably cheap fix. Llama 4x4 do replacement mounts if required.
1988 Samurai - Truck Cab & Tray Back - 1.6 8v & HIF44 - Snorkel - Stack Exhaust - PAS, YJs & 33s - Trussed, Gusseted & Pumpkin Capped Axles - 4.3 R&Ps - 4.16 T/Box - Rear Air Locker - Full Float Back Axle & Discs - RCV Front Shafts - X-Eng Handbrake - Custom Fuel Tank
-
twiss
- SCUK Computer Wizard
- Posts: 6110
- Joined: Mon Nov 08, 2010 2:28 pm
- Location: Birkirkara, Malta
- Contact:
Re: Transfer box gear lever shake
Either that or if the mounts are OK, the plastic shifter sheet/boot underneath the stick might be knackered.
Again pretty easy and cheap to replace, you should be able to get a kit from suzuki with the springs, boot, and some ball bearings for about £10?
Again pretty easy and cheap to replace, you should be able to get a kit from suzuki with the springs, boot, and some ball bearings for about £10?
Twiss
'93 Suzuki Samurai Sport 1.6 16v SU. Virtual lift, spring under, 31s
'93 Maruti Gypsy MG410
"If brute force doesn't fix your problem, you aren't using enough of it."
'93 Suzuki Samurai Sport 1.6 16v SU. Virtual lift, spring under, 31s
'93 Maruti Gypsy MG410
"If brute force doesn't fix your problem, you aren't using enough of it."
Re: Transfer box gear lever shake
Ta for the advice, will have an investigate!
-
Anton
- I spend far too much time on here
- Posts: 3859
- Joined: Tue Jan 12, 2010 12:12 pm
- Location: London
Re: Transfer box gear lever shake
Are you certain you're in 2wd? After a violent hillstart in the south downs, mine popped out of 2wd into 4wd hi and the lever shook like mad - I thought I'd blown my t-case mounts, but checked it was in 2wd - it wasn't - and when I put it back into 2wd, the shake went away.
1985 SJ413VX (SJ50V) with SPOA, rear disc brakes, 31x10.5R15 Kaiman Malatesta tyres, an MOT and a lot left to do!
My: Build thread ● To-do list ● Pay and Play map
My: Build thread ● To-do list ● Pay and Play map